Home » Company profile » News & Events » References » Research & Articles » Videos » Brochures » Links » Contact us » Distributors »
Friday, 25.July 06:11  (GMT +02:00)
PRODUCTS & SOLUTIONS
Ventilation hygiene inspection, air duct cleaning equipment
Healthy building, sick building syndrome (SBS), disinfecting, sterilising and dehumidification
Sick building syndrome
Disinfecting, sterilising
Dehumidification
Renovation hygiene
Air filtration
Building protection
Grease duct cleaning, kitchen extract
Healthy building, sick building syndrome (SBS), disinfecting, sterilising and dehumidification
Renovation hygiene

Development of safe repair methods for water damaged buildings

Ilpo Kulmala (1), Antti Souto (2), Vesa Mäkipää (2)

(1) VTT Automation, (2) Oy Lifa Air Ltd

Abstract

Efficient control methods are needed to prevent harmful microbes and other airborne contaminants from spreading to adjacent areas during the renovation of water-damaged buildings. Such methods are important, especially when exposure to microbes can create a severe risk to susceptible people, such as immune-compromised patients. In this study safe repair and drying methods were evaluated during remediation work in a hospital. The work area was sealed and maintained under negative pressure by a recently developed air-handling unit that can clean and dry air. The microbe and dust concentrations were high in the construction area during removal operations, about 10 4 - 10 5 cfu/m3 and 100 mg/m3, respectively. The respective concentrations in the exhaust air of the air-handling unit were < 10 cfu/m3 and 0.002 mg/m3; therefore, with proper control techniques, very high control efficiencies can be achieved.

KEYWORDS: renovation, dust, mould, dehumidification, filtration

Intoroduction

Water damage occurs frequently in buildings. It is often caused by plumbing leaks, due to leaky foundation walls, poor flashing details at wall junctions, inadequate foundation drainage, and other construction defects. Prolonged moisture build-up often occurs when leaks go unnoticed within the wall itself even though the moisture is not manifest itself on any interior surface. This moisture build-up often results in microbial growth. Exposure to airborne spores of such microbes can cause several adverse health effects. These effects depend on the fungal species and on the dose and duration of the exposure and include respiratory infections, eye and mucous membrane irritation, allergic diseases, and organic dust toxic syndrome. Another contributing factor to these adverse health effects is suspected to be the metabolites produced by the microbes. The proper management of water damage includes eliminating the water source, removing mouldy materials and drying the wet structures. Drying is usually expedited with the aid of a dehumidifier, which reduces the relative humidity by removing moisture from the air. If the removal work is done without any control methods, the airborne microbes can spread to the surroundings of the site and cause potentially massive exposure of building occupants or residents [1]. Such exposure is a severe health risk to susceptible people, for example, transplant patients receiving immune-suppressive therapy or cancer care patients in hospitals, especially when the microbes contain fungi of the species Aspergillus fumigatus or Aspergillus flavus [2].

One control method currently used in the removal of mouldy materials involves sealing the area in enclosures maintained under negative pressure by exhaust systems discharging to the surrounding or outside air through efficient filter systems. The negative pressure is commonly created with air-handling units that are equipped with HEPA filters rated at 99.97% for 0.3 µm particles and designed for asbestos abatement work. These devices are not, however, particularly suitable for water-damage repairs. For example, in damp and dusty environments microbial growth on HEPA filters can ruin the filters and produce odours (Mäkipää, personal communication).

The objective of this study was to develop a safe repair method for demanding applications in areas where very high control efficiency is needed, such as in hospitals and day-care centres. For this purpose, a new innovative portable air-handling unit was designed and constructed. It combines a dehumidifier with a filtration unit. It consists of a prefilter, dehumidifier, a HEPA filter and a fan. An optional gas filter is available which removes the odours produced by the metabolism of the moulds. The dehumidifier is of the refrigerant type that cools the air to a temperature below its dew point so that water vapour condenses on the evaporator coils and is removed with an automatic pump-out system. It is placed upstream of the HEPA filter so that the relative humidity of the air drawn through the filter is so low that microbial growth is prevented

Methods

The efficiency of the developed control method was evaluated during water-damage repair work in a hospital. Two washrooms were repaired. The evaluation included measurements of airborne microbes, total dust and volatile organic compounds (VOC) during the removal and drying stages. Before any renovation work was started, the doors to the washrooms were removed, and the space was isolated with temporary plastic sheeting walls. To prevent the escape of airborne contaminants from the removal area enclosure, a portable air-handling unit was installed to maintain a negative pressure of about 5 Pa within the working area. The exhaust air was discharged into a separate measurement chamber and further into the indoor space. Therefore, the exhaust air was prevented from mixing with the surrounding air so that the exhaust air samples could be taken accurately. With the aid of the measurement chamber and a real-time aerosol photometer, the possible leaks and failures in the filtration unit could be monitored and rapidly detected. Another portable air-handling unit was adjusted at a slightly lower airflow rate and used to supply replacement air. Filtering the incoming air, also helped minimize the effect of ambient air contaminant concentrations on the results. The principle of the arrangements is shown in Figure 1.

Figure 1. Arrangement of the enclosures during the removal and drying operations. The air-sampling points are identified by the following numbers: 1= washroom, 2=enclosure, 3=exhaust air chamber.

During the removal work, a pneumatic drill was used to break up the floor pavement. The tiles were removed with a drill-hammer. All the removed material was bagged before transport to the disposal site. The workmen entered the area through an airlock. Within the work site the workers wore protective clothing and used powered positive-pressure filtration units.

After the demolition and clean-up, the plastic temporary walls were removed and the drying phase was started. At this stage the portable air-handling units were placed inside the washroom to expedite the drying process. The washroom to be dried was kept under slightly negative pressure by discharging part of the exhaust air outside the washroom (Figure 1).

Measurement of airborne contaminants

The efficiency of the control method for various contaminants was evaluated by measuring the airborne microbe, total dust and VOC concentrations, both in the washroom and in the exhaust air. In addition, during the drying phase, the air temperature and humidity were measured.

The total dust concentration was measured using a standard filter method. The samples were collected on open-face cassettes with a diameter of 37 mm. The exhaust air concentration was also continuously monitored with an aerosol photometer to find possible leaks in the air handling unit (TSI Dust Trak, model 8520).

The airborne microbe concentrations were determined by collecting the samples directly the cultivation media with a six-stage cascade impactor. Three different media were used for culturing specific microbes: Rose Bengal-malt-extract and dichloran glycerol agar (DG18) for mesophilic fungi and Tryptone-yeast-glucose (TYG) agar for mesophilic bacteria. After the sampling, the fungal culture plates were incubated at 25ºC for 7 days. The fungal colonies were calculated and the genus identified with an optical microscope.

The VOC concentrations were measured by collecting samples on Tenax tubes. After the sampling, the exposed tubes were thermally desorbed and analyzed by the gas chromatography - mass selective detection method. The total VOC (TVOC) concentrations were determined as the toluene equivalent.

Results

The total dust concentrations are shown in Figure 2, and the microbe concentrations are presented in Figure 3.

From Figure 2 it can be seen that the total dust concentrations were very high during the removal operations, the mean level being more than 100 mg/m3. The concentrations in the enclosure (measuring point 2) were somewhat lower than in the washrooms, but they clearly exceeded the Finnish exposure limits for in-organic dust (10 mg/m3 ). Thanks to the efficient filtration of the exhaust air, the concentrations in the exhaust air of the air-handling unit were very low, on the average 0.002 mg/m3.


Figure 2. Mean total dust concentrations. The standard deviations are shown by vertical bars.


Figure 3. Measured microbe concentrations.

The microbe concentrations in the washroom were normal before the remediation work and the genus consisted of typical species. During the demolition work the concentration levels increased and the commonest isolated fungal genus became Aspergillus, followed by Pe-nicillium, and Acremonium. Of the mesophilic bacteria, the commonest was Streptomycetes. In the exhaust chamber the concentrations were low, below 10 cfu/m3. The microbe levels in the washroom were also lower during the drying phase than before the renovation work began.

The TVOC concentrations in the washroom were 2050 µg/m3 before the remediation. The highest concentration was detected for an aliphatic hydrocarbon solvent (880 µg/m3) that had been a component of the detergent used in the washroom. During the removal work the TVOC concentration decreased to 240 µg/m3, and during the drying phase it was further reduced to 70 µg/m3. This decrease is likely due to the removal of contaminant sources and the filtration of the air.

During the drying phase the temperature and relative humidity (RH) were measured both in the washroom and in the adjacent corridor. The drying phase took one week, and during it the temperature varied in the corridor from 22 to 25ºC, and the RH ranged between 40% and 60%. The temperature in the washroom was few degrees higher than in the corridor. When the dehumidifier was first put into operation, the RH in the washrooms decreased rapidly, but after about eight hours it levelled off to between 30% and 35%.

Discussion

The results are in agreement with previous findings in that demolition inevitably disrupts loci or fungal growth or the accumulations of spores and releases them into the indoor air [1]. The inorganic dust emission rates can also be very high. Therefore effective control measures are needed to prevent these contaminants from spreading to adjacent areas and causing potentially massive exposure among residents or occupants. The developed work method was devised for critical applications in such places as hospitals, but it can also be used on less demanding renovation sites.

The results show that, by carefully isolating of the work area, maintaining a negative pressure within it and filtering the exhaust air, one can efficiently prevent the escape of contaminants, and thereby eliminate the need to evacuate occupants during renovation work. However, the use of an asbestos-abatement type of negative air unit during the handling of mouldy materials can cause significant problems. Professional experience has shown that, under conditions in which both nutrients and high humidity are present, microbes can grow on HEPA filters and cause potential exposure to the metabolites of the microbes. Moreover, the negative air units designed for asbestos work do not remove gaseous contaminants. These drawbacks can be avoided with the apparatus presented in this paper since it helps prevent conditions favourable for microbial growth and amplification. Another benefit of the new apparatus is that only one air-handling device is needed in place of a separate dehumidifier and filtration unit, and therefore the space required by the machinery is reduced. These devices have been used for about a year, and so far no mould growth has been observed. The selection of control strategies for renovation activities depends on the type and size of the project, the type of contaminants and the consequences of occupant and equipment exposure. However, in many cases, water damage is hidden, and the hazards due to microbial contamination cannot be predicted. Therefore, to avoid fatal errors, renovation work should be done using effective control techniques, particularly in situations in which exposure can have severe consequences.

The techniques and apparatus may also be used to reduce the curing time of paints and maintain a comfortable work environment during finishing work, but additional studies are needed to verify this.

Acknowledgements

This study belongs to the Healthy Buildings technology programme and was financially supported by Tekes.

References

1. Rautiala, S., Reponen, T., Hyvärinen, A. et al. 1996. Exposure to airborne microbes during the repair of moldy buildings. Am. Ind. Hyg. Assoc. J. Vol 57:279-284. 2. Kuehn, T., Cacek, B., Yang, C., et al. 1996. Identification of Contaminants, Exposures, Effects, and control options for construction/renovation activities. AshraeTransactions. Vol. (2), pp. 89 - 101.


Measuring results of Healthy Building -project

Lifa Dry&CLean in use

1. Concentration inside the working area before renovation

2. Concentration inside the working area during renovation

3. Concentration in the Lifa Dry&Clean exhaust air during renovation

4. Concentrations of airborne fungi spores and bacteria (cfu/m3)


Measuring results of Healthy Building -project

Lifa Dry&Clean in use, dust concentrations in the air.

1. Concentration before starting the renovation.

2. Concentration before starting the renovation in the working area.

3. Concentration in the Lifa Dry&Clean exhaust air during renovation.

© Lifa Air Ltd